Microwave: practical cost-effectivemethod for sterilizing urinary catheters in the home

doi:10.1016/0090-4295(90)80035-L

Urology

Volume 35, Issue 3, March 1990, Pages 219-222

https://doi.org/10.1016/0090-4295(90)80035-L Get rights and content

Abstract

We used a standard microwave oven to sterilize red rubber catheters used for intermittent self-catheterization. Catheters were incubated for sixty minutes in a suspension of microorganisms isolated from the urine of patients with urinary tract infections. For each trial, 6 catheters were removed from their respective suspensions, placed in separate plastic freezer bags, distributed evenly in a microwave oven (avoiding cold spots), and microwaved simultaneously for twelve minutes. A control catheter was not microwaved. Two strains of each microorganism were tested. The urinary isolates were Escherichia coli, Klebsiella sp., Proteus sp., Enterobacter sp., Pseudomonas sp., Streptococcus sp., Staphylococcus sp., and Candida sp. In each experiment, all 6 catheters were sterilized. Repeat sterilization in the microwave oven did not affect the integrity of the catheters or the plastic bags. A water heat sink of constant volume was employed. A home microwave oven may be used as a method to sterilize red rubber catheters for reuse with a recommended time of twelve minutes at full power. This technique makes aseptic intermittent self-catherization a practical possibility.

References (11)

LapidesJ.D. et al.
Follow-up upon unsterile intermittent self-catheterization
J Urol
(1974)
RohrerM.D.
Microwave sterilization of hydrophilic contact lenses
Am J Ophthal
(1986)
RohrerM.D. et al.
Microwave sterilization
JAMA
(1985)
SilbarE.C. et al.
Microwave sterilization: a practical cost effective method for home sterilization of urinary catheters
J Urol
(1989)
LohmannS. et al.
Microwave sterilization of vials
J Parenteral Sciences Tech
(1986)

There are more references available in the full text version of this article.

Cited by (21)

Adequacy of sanitization and storage of catheters for intermittent use after washing and microwave sterilization
2009, Journal of Urology
Citation Excerpt :
This rate was based on a substantial bacterial burden, which likely exceeded 108 cfu. In contrast, some groups observed complete eradication of test organisms after microwave sterilization.3,4 In a review of catheter sanitation practices Bogaert et al noted that microwave heating was only bactericidal against E. coli and not Pseudomonas aeruginosa or Staphylococcus aureus.6
Clean intermittent catheterization is used to treat neurogenic bladders and it can be adequate to maintain sterile urine. Typically polyvinylchloride, individually packaged catheters are used but they are not intended for repeat use by the manufacturer. Antibacterial soap alone or combined with microwave heating was advocated to decrease pathogens and bacterial residue, which could inoculate the bladder from a colonized catheter. We assessed the efficacy of catheter sanitizing and storage for reuse.
Catheters were inoculated with a 24-hour broth culture of Escherichia coli and washed in antibacterial soap, washed and microwaved or immediately packaged (positive controls) and stored for 1, 3 and 7 days, respectively. Common packaging was used, including paper towels, sealable plastic bags or sealable rigid plastic containers. Each condition was assessed in triplicate via culture of the entire catheter contents, yielding a total of 27 catheters per sanitization method.
Antibacterial wash alone failed to sanitize 67% of catheters (6 of 9 with 2 of 3 positive per container) on day 1, 22% (2 of 9 with all positive catheters in a paper towel) on day 3 and 44% (4 of 9 with 1 in a paper towel and 3 in a plastic container) on day 7. For combined antibacterial wash and microwave heating the positive rate was 0% (0 of 9 catheters) on day 1, 22% (2 of 9 in a plastic container) on day 3 and 56% (5 of 9 with 3 in a paper towel, 1 in a plastic bag and 1 in a plastic container) on day 7. Positive untreated controls showed viable organisms throughout the test period.
Overall 44% of catheters (12 of 27) washed with antibacterial soap yielded E. coli vs 26% (7 of 27) with combined antibacterial soap-microwave treatment. The latter is a more effective but not an absolute way to sanitize catheters for intermittent use. Longer storage time increased the risk of E. coli growth on the catheters.
The physical and antimicrobial effects of microwave heating and alcohol immersion on catheters that are reused for clean intermittent catheterisation
2004, European Urology
Due to worldwide different health insurance policies, patients are often forced to reuse the catheters when performing Clean Intermittent Catheterisation (CIC). We have compared the physical qualities and the antimicrobial effects of two methods of reusing catheters: microwave heating and storage of the catheters in a 70% alcohol solution. The studies were performed during different lengths of time.
Three types of catheters (a standard polyvinylchloride catheter, a special polyvinylchloride catheter with flexible Ergothan^® tip and a prelubrified catheter), normally intended for single use, were submitted to the effect of a microwave oven (Multitech 215 High Grade and Whirlpool M220 750 W and 1000 W with rotating plate) or preservation in a 70% alcohol solution. To study the effects of microwave heating, a recipient of water was placed in the oven to spread the microwaves and to absorb the heat. The catheters were placed in a resealable plastic bag (Ziploc^®). To study the effects of preservation in a 70% alcohol solution, the catheters were immerged in the solution for different lengths of time. Thereafter were the physical qualities of the catheters evaluated by using the technique of Differential Scanning Calorimetry (DSC). The antimicrobial effect of the method was evaluated after grafting the catheters with pathogenic E. coli, P. aeruginosa or S. aureus strains.
Microwave heating up to 12 minutes at 750 W caused only minimal changes in the physical qualities of all the catheters. However, there was only an antimicrobial effect of the microwave heating on E. coli and not on P. aeruginosa or S. aureus. If the catheter remained longer than 45 minutes in a 70% alcohol solution, the physical qualities of the catheter changed either minimal in the special polyvinylchloride catheter with flexible Ergothan^® top but changed significantly in the prelubrified catheter). However, already after 5 minutes of immersion in the 70% alcohol solution there was a complete antimicrobial effect on E. coli, P. aeruginosa and S. aureus in all catheters.
It should be recommended to patients on CIC to use a sterile packed and not previously used catheter. In this study we have shown that immersing the catheters in a 70% alcohol solution during 5 minutes can effectively disinfect the catheter without jeopardising the physical qualities. Thereafter, the catheters could be placed in a resealable (e.g. Ziploc^®) bag without being rinsed under water, in order that the few drops of alcohol cause alcohol vapours within the closed plastic bag and maintain the antimicrobial effect.
Variability in catheter microwave sterilization techniques in a single clinic population
2002, Journal of Urology
We designed a survey to assess the microwave sterilization technique practiced by patients at our clinic who perform clean intermittent catheterization.
A 23-question survey addressing urinary catheter use and home sterilization techniques was mailed to 129 patients. A followup survey was mailed to 47 respondents who reported using a microwave oven to sterilize the catheters to assess the microwave technique further.
Of the 129 initial surveys 84 (64%) were returned, while 40 (85%) of the 47 followup questionnaires on microwave sterilization were returned. All patients surveyed have used clean intermittent catheterization for at least 1 year and 75% have used it more than 5 years. Of the respondents 80% perform clean intermittent catheterization 4 to 5 times daily, although sterilization frequency varies from daily to less than once weekly. Of the respondents 71% reported no difficulty with microwave sterilization, although 31 (63%) reported a history of catheter melting during microwaving. Of the respondents 35% reported using a rotation table, all used a heat sink containing 1/2 to 4 cups of water, 39% used 500 to 1,000 W., 37% used greater than 1,000 W., 73% set the microwave for 6 minutes, others set it for 3 to 30 minutes and 98% used a power setting described as high, full, 10 or 100%.
Significant variation exists in the cleaning and sterilizing techniques used by our patients, although they were given uniform written and verbal instructions. It is unclear from the data in the literature how this variation affects sterilization.
Nursing interventions for Urinary Incontinence in home health
1999, Journal of Wound, Ostomy and Continence Nursing
Urinary incontinence (UI) is a significant health care issue among older patients in the acute care, extended care, and home care settings. With the shift toward health care delivery in the home setting, it is becoming increasingly necessary for home health care professionals to become knowledgeable about the causes, assessment, and treatment. This article will review the epidemiology, causes, assessment, and management of UI in the home care setting. Emphasis is placed on the role of the WOC nurse as coordinator of a multidisciplinary team providing care of the home bound patient with UI.
The in vitro bactericidal effect of microwave energy on bacteria that cause prostatitis
1998, Urology
Objectives. We investigated the in vitro nonthermal effects of microwaves delivered from Prostatron 2.0 on Escherichia coli and Enterobacter cloacae.
Methods. The fingers of powder-free, sterile gloves were ligated, and bacterial solutions were transferred into the remaining area of the glove. The gloves were then sealed using silk ligatures. One set of gloves was subjected to the microwave treatment while another set was placed in a temperature-matched waterbath to act as control samples. The gloves containing the treatment group were taped around the probe, at the site where microwave energy exits the probe. During the treatment period, the temperatures from the urethral probe and the rectal probe were carefully monitored.
Results. The mean (±SD) energy delivered was 46.6 ± 9.5 kJ (range 30.0 to 59.5) for the 10 trials on E. coli and colony counts in the experimental microwaved gloves decreased significantly compared with control samples (5.26 ± 4.5 × 10⁵ versus 10.16 ± 9.3 × 10⁵ CFU/mL, P = 0.02). For the experiments on E. cloacae the mean (±SD) energy applied was 38.5 ± 12.5 kJ, and a significant decrease in colony counts of microwaved samples was also observed compared with controls (11.04 ± 4.8 × 10⁵ versus 20.08 ± 10.1 × 10⁵ CFU/mL, P = 0.004).
Conclusions. Microwave energy, delivered from Prostatron 2.0, independent of heat production has an in vitro bactericidal effect on laboratory-cultured E. coli and E. cloacae.
Killing activity of microwaves in milk
1996, Journal of Hospital Infection
The killing activity of microwaves of 2450 MHz frequency and 600 W power on Pseudomonas aeruginosa, Escherichia coli, Enterobacter sakazakii, Klebsiella pneumoniae, Staphylococcus aureus, Candida albicans, Mycobacterium terrae and poliomyelitis vaccine-virus suspended in five infant formula preparations was investigated. The samples were brought to the boil (85–100 s depending on milk type). They had reached average temperatures of 82–93 °C at this point. Most of the vegetative organisms were killed. In those samples where growth was still detectable after microwave treatment, a significant reduction in viable micro-organisms (at least 5000-fold) was noted. We conclude that microwave heating to the boil is a convenient and fast method to reduce microbial contamination of infant feeds. However, care should be taken to ensure that milk is adequately cooled to the required temperature before it is fed to an infant.

View all citing articles on Scopus

View full text

Scientific articleMicrowave: practical cost-effectivemethod for sterilizing urinary catheters in the home

Abstract

J Urol

Am J Ophthal

JAMA

J Urol

Microwave sterilization of vials

J Parenteral Sciences Tech

Scientific article
Microwave: practical cost-effectivemethod for sterilizing urinary catheters in the home